Friedrich CP05A10 Manual de usuario

Room Air ConditionerService and PartsManual CP05 / CP06 (06/05)CP05A10 CP06A10

2.4.2 EVAPORATOR/CONDENSER1. Remove the cabinet.2. Discharge the refrigerant by using a refrigerantrecovery system.3. Remove the air guide upper. (Ref

—11—Equipment needed: Vacuum pump, charging cylinder, manifold gauge, brazing equipment, pinch-off tool capableof making a vapor proof seal, leak dete

—12—3. TROUBLESHOOTING GUIDE3.1 OUTSIDE DIMENSIONS (unit: mm [in]) 370 (14 9/16")312 (12 1/4")370 (14 9/16")312 (12 1/4")29 (1 5/3

—13—3.2 PIPING SYSTEMFollowing is a brief description of the important components and their function in what is called the refrigerationsystem. Refere

—14—3.3 TROUBLESHOOTING GUIDE In general, possible trouble is classified in two categories. The one is called Starting Failure which is caused by an e

—15—Fails to Start Improper thermostat setting Loose terminal connection Improper wiring Check power source. Drop of power voltage. Capacitor check.

COMPLAINT CAUSE REMEDY Fan motor will not run. No power Check voltage at outlet. Correct if none. Power supply cord Check voltage to rotary switch

—17—COMPLAINT CAUSE REMEDY Fan motor noise. Fan If cracked, out of balance, or partially missing, replace it. Blower If cracked, out of balance,

—18—COMPLAINT CAUSE REMEDY Compressor cycles on Fan motor If not running, determine the cause. Replace if overload. required. Condenser air flow R

—19—4. CIRCUIT DIAGRAM WH(BL)POWER INPUTBK(BR)(Ribbed) (Plain)GN/YL(GN)GN/YL(GN)THERMISTORBK BKBLRDBLRDCN-TH1YL YLOR(BR) OR(BR)ORSYNCMOTORRY-LORY-HICN

—2—CONTENTS 1. PREFACE ...

—20—5. EXPLODED VIEW352390130410359012W48602354210349480352380149980559011346811554030W4860213091055014055416056750235211535211135211335211A1353131523

—21—6. SERVICE PARTS LIST • CP05A10 CP06A10R: Service PartsN: Non Service Parts • Loc No FRIEDRICH Description 130410 67302921 BASE

Loc No FRIEDRICH Description130410 67302921 BASE ASSEMBLY,WELD[SINGLE]130910 67303709 CABINET ASSEMBLY,SINGLE135312 67306008 GRILLE ASSEMBLY,FRONT(SIN

—23—MEMO

Post Office Box 1540 • 4200 N. Pan Am Expressway • San Antonio, Texas 78295-1540 • (210) 357-4400 • FAX (210) 357-4490FRIEDRICH AIR CONDITI

—3—1. PREFACE This service manual provides various service information, including the mechanical and electrical parts, etc. This room air conditioner

—4—1.3 LOCATIONS OF CONTROLS 1.4 SAFETY PRECAUTIONS 1. When servicing, turn the unit Off and unplug the power cord. 2. Observe the original lead dres

—5—2. DISASSEMBLY INSTRUCTIONS 2.1 MECHANICAL PARTS 2.1.1 FRONT GRILLE 1. Pull the inlet grille forward.2. Remove the screw securing the Front Grille.

—6—2.2 AIR HANDLING PARTS 2.2.1 AIR GUIDE UPPER 1. Disconnect the unit from the power source.2. Remove the front grille. (Refer to Section 2.1.1)3.

—7—2.2.3 MOTOR1. Disconnect the unit from the power source.2. Remove the front grille. (Refer to Section 2.1.1)3. Remove the cabinet. (Refer to Sectio

—8—2.3.2 COMPRESSOR 1. Remove the front grille and cabinet. (Refer to Section 2.1) 2. Discharge the refrigerant by using a refrigerantrecovery system.

—9—2.3.6 POWER CORD1. Disconnect the unit from source of power.2. Remove the front grille. (Refer to Section 2.1.1)3. Remove the cabinet. (Refer to Se